http://www.legislation.gov.uk/id/eur/2016/1718/adopted

ANNEX IV

Annex XI to Regulation (EU) No 582/2011 is amended as follows:

(1)
point 4.3.2.4 is replaced by the following:
4.3.2.4.Durability of emissions performance
The exhaust after-treatment system tested in accordance with point 4.3.2.2 and incorporating the replacement pollution control device shall be subjected to the durability procedures described in Appendix 3.
(2)
the following point 4.3.5 is inserted:
4.3.5.Fuels
In the case described in point 1.1.2 of Annex I, the test procedure laid down in points 4.3.1 to 4.3.2.7 of this Annex shall be conducted with the fuels declared by the manufacturer of the original engine system. However, in agreement with the type-approval authority, the durability procedure set out in Appendix 3 and referred to in point 4.3.2.4 may be performed only with the fuel which represents the worst case in terms of ageing.
(3)
the following points 4.6 to 4.6.5 are inserted:
4.6.Requirements regarding compatibility with the NO_x control measures (applicable only to replacement pollution control devices to be fitted to vehicles equipped with sensors directly measuring NO_x concentration in the exhaust)
4.6.1.
NO_x control measures compatibility demonstration is required only when the original pollution control device was monitored in the original configuration.
4.6.2.
The compatibility of the replacement pollution control device with the NO_x control measures shall be demonstrated by using the procedures described in Annex XIII to this Regulation, for replacement pollution control devices intended to be fitted to engines or vehicles type-approved in accordance with Regulation (EC) No 595/2009 and this Regulation.
4.6.3.
The provisions in UN/ECE Regulation No 49 applicable to components other than pollution control devices shall not apply.
4.6.4.
The replacement pollution control device manufacturer may use the same preconditioning and test procedure as used during the original type-approval. In that case, the approval authority which granted original type-approval of an engine of a vehicle shall provide, on request and on a non-discriminatory basis, an information document presented as an appendix to the Information Document provided for in Appendix 4 to Annex I, which contains the number and type of preconditioning cycles and the type of test cycle used by the original equipment manufacturer for NO_x control measures testing of the pollution control device.
4.6.5.
Point 4.5.5 shall apply to NO_x control measures monitored by the OBD system.

(4)

Appendix 3 is replaced by the following:

‘Appendix 3Durability procedure for evaluation of emissions performance of a replacement pollution control device
1.
This Appendix sets out the durability procedure referred to in point 4.3.2.4 of Annex XI, for the purpose of evaluating the emissions performance of a replacement pollution control device.
2.DESCRIPTION OF THE DURABILITY PROCEDURE
2.1.
The durability procedure shall consist of a data collection phase and a service accumulation schedule.
2.2.Data collection phase
2.2.1.
The selected engine, equipped with the complete exhaust after-treatment system incorporating the replacement pollution control device, shall be cooled down to ambient temperature and run one cold start WHTC test-cycle in accordance with paragraphs 7.6.1 and 7.6.2 of Annex 4 to UN/ECE Regulation No 49.
2.2.2.
Immediately after the cold start WHTC test-cycle, the engine shall be run for nine consecutive hot start WHTC test-cycles in accordance with paragraph 7.6.4 of Annex 4 to UN/ECE Regulation No 49.
2.2.3.
The test sequence set out in points 2.2.1 and 2.2.2 shall be carried out in accordance with the instructions laid down in paragraph 7.6.5 of Annex 4 to UN/ECE Regulation No 49.
2.2.4.
Alternatively, the relevant data can be collected by driving a fully loaded vehicle equipped with the selected exhaust after-treatment system incorporating the replacement pollution control device. The test can be carried out either on the road following the trip requirements of points 4.5 to 4.5.5 of Annex II to this Regulation with comprehensive recording of the driving data, or on a suitable chassis dynamometer. If an on-road test is chosen, the vehicle shall be driven over a cold test-cycle, as set out in Appendix 5 to this Annex, followed by nine hot test-cycles, identical to the cold one, in a way that the work developed by the engine is the same as the one achieved under points 2.2.1 and 2.2.2. If a chassis dynamometer is chosen, the simulated road gradient of the test-cycle in Appendix 5 shall be adapted to match the work developed by the engine over the WHTC.
2.2.5.
The type-approval authority shall refuse the temperature data obtained under point 2.2.4 if it deems those data to be unrealistic and shall request either the repetition of the test, or the carrying out of a test pursuant to points 2.2.1, 2.2.2 and 2.2.3.
2.2.6.
Temperatures in the replacement pollution control device shall be recorded during the whole test sequence, at the location with the highest temperature.
2.2.7.
In cases where the location with the highest temperature varies over time, or where that location is difficult to define, multiple bed temperatures should be recorded at suitable locations.
2.2.8.
The number and locations of the temperature measurements shall be selected by the manufacturer, in agreement with the type-approval authority, based on best engineering judgement.
2.2.9.
With the agreement of the type-approval authority, a single catalyst bed temperature or the catalyst inlet temperature may be used if measuring multiple bed temperatures is proven to be unfeasible or too difficult.
Figure 1
Example of temperature sensors location in a generic after-treatment device
Figure 2
Example of temperature sensors location for DPF
2.2.10.
The temperatures shall be measured and recorded at a minimum rate of once every second (1 Hz) during the test sequence.
2.2.11.
The measured temperatures shall be tabulated into a histogram with temperature bins no larger than 10 °C. In the case mentioned in point 2.2.7, the highest temperature each second shall be the one recorded in the histogram. Each bar of the histogram shall represent the cumulated frequency in seconds of the measured temperatures falling in the specific bin.
2.2.12.
The time in hours corresponding to each temperature bin must be determined and then extrapolated to the useful life of the replacement pollution control device, in accordance with the values specified in Table 1. The extrapolation shall be based on the assumption that one WHTC cycle corresponds to 20 km driving.
Table 1Useful life of the replacement pollution control device for each vehicle category, and equivalent WHTC test-cycles and hours of operation
Vehicle category
Mileage (km)
Equivalent number of WHTC test-cycles
Equivalent number of hours
Engine systems fitted to vehicles of category M₁, N₁ and N₂
114 286
5 714
2 857
Engine systems fitted to vehicles of category N₂, N₃ with a maximum technically permissible mass not exceeding 16 tonnes and M₃ Class I, Class II and Class A, and Class B with a maximum technically permissible mass exceeding 7,5 tonnes
214 286
10 714
5 357
Engine systems fitted to vehicles of category N₃ with a maximum technically permissible mass exceeding 16 tonnes, and M₃, Class III and Class B with a maximum technically permissible mass exceeding 7,5 tonnes
500 000
25 000
12 500
2.2.13.
It is allowed to perform the data collection phase for different devices at the same time.
2.2.14.
In the case of systems operating in the presence of active regeneration, the number, length and temperatures of the regenerations occurring during the test sequence defined in points 2.2.1 and 2.2.2 shall be recorded. If no active regeneration has occurred, the hot sequence defined in point 2.2.2 shall be extended in order to include at least two active regenerations.
2.2.15.
The total lubricant consumed during the data collection period, in g/h, shall be recorded, using any suitable method, as for example the drain and weigh procedure described in Appendix 6. For this purpose, the engine shall be run during 24 hours, performing consecutive WHTC test-cycles. In cases where an accurate measurement of oil consumption cannot be obtained, the manufacturer, in agreement with the type-approval authority, may use the following options for the determination of the lubricant consumption:
(a)
a default value of 30 g/h;
(b)
a value requested by the manufacturer, based on sound data and information, and agreed with the type-approval authority.
2.3.Calculation of the equivalent ageing time corresponding to a reference temperature
2.3.1.
The temperatures recorded pursuant to points 2.2 to 2.2.15 shall be reduced to a reference temperature T_r, requested by the manufacturer in agreement with the type-approval authority, within the range of the temperatures recorded during the data collection phase.
2.3.2.
In the case specified in point 2.2.13, the value of T_r for each one of the devices may vary.
2.3.3.
The equivalent ageing time corresponding to the reference temperature shall be calculated, for each bin referred to in 2.2.11, in accordance with the following equation:
Equation 1:
$t_{i}^{e} = t_{i}^{bin} \times e^{((\frac{R}{T_{r}}) - (\frac{R}{T_{i}^{bin}}))}$
Where:
R
thermal reactivity of the replacement pollution control device.
The following values shall be used:
Diesel oxidation catalyst (DOC): 18 050
Catalysed DPF: 18 050
SCR or ammonia oxidation catalyst (AMOX) based on iron-zeolite (Fe-Z): 5 175
SCR copper-zeolite (Cu-Z): 11 550
SCR Vanadium (V): 5 175
LNT (lean-NO_x trap): 18 050
T_r
reference temperature, in K.
$T_{i}^{bin}$
mid-point temperature, in K, of the temperature bin i to which the replacement pollution control device is exposed during the data collection phase, registered in the temperature histogram.
$t_{i}^{bin}$
the time, in hours, corresponding to the temperature $T_{i}^{bin}$ , adjusted to a full useful life basis e.g. if the histogram represented 5 hours, and useful life is 4 000 hours according to Table 1, all histogram time entries would be multiplied by $\frac{4000}{5} = 800$ .
$t_{i}^{e}$
the equivalent ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device at the temperature $T_{i}^{bin}$ during the time $t_{i}^{bin}$ .
i
bin number, where 1 is number for the bin with the lowest temperature and n the value for the bin with the highest temperature.
2.3.4.
The total equivalent ageing time shall be calculated in accordance with the following equation:
Equation 2:
$AT = \sum_{i = 1}^{n} t_{i}^{e}$
Where:
AT
total equivalent ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device, over its useful life, to the temperature $T_{i}^{bin}$ during the time $t_{i}^{bin}$ of each one of the i bins registered in the histogram.
$t_{i}^{e}$
the equivalent ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device at the temperature $T_{i}^{bin}$ during the time $t_{i}^{bin}$ .
i
bin number, where 1 is number for the bin with the lowest temperature and n the value for the bin with the highest temperature.
n
Total number of temperature bins.
2.3.5.
In the case referred to in point 2.2.13, AT shall be calculated for each device.
2.4.Service accumulation schedule
2.4.1.General requirements
2.4.1.1.
The service accumulation schedule shall allow acceleration of the ageing of the replacement pollution control device, using the information gathered during the data collection phase set out in point 2.2.
2.4.1.2.
The service accumulation schedule shall consist of a thermal accumulation schedule and a lubricant consumption accumulation schedule in accordance with point 2.4.4.6. The manufacturer, in agreement with the type-approval authority, may not have to carry out a lubricant consumption accumulation schedule in case the replacement pollution control devices are placed downstream of an after-treatment filter component (e.g. diesel particulate filter). Both the thermal accumulation schedule and the lubricant consumption accumulation schedule shall consist of a repetition of, respectively, a series of thermal and lubricant consumption sequences.
2.4.1.3.
In the case of replacement pollution control devices operating in the presence of active regeneration, the thermal sequence shall be complemented with an active regeneration mode.
2.4.1.4.
For service accumulation schedules consisting of both thermal and lubricant consumption accumulation schedules, their respective sequences shall be alternated, so that for each thermal sequence that has to be performed, the following sequence corresponds to lubricant consumption.
2.4.1.5.
It is allowed to perform the service accumulation schedule at the same time for different devices. In that case, a single service accumulation schedule shall be set for all the devices.
2.4.2.Thermal accumulation schedule
2.4.2.1.
The thermal accumulation schedule shall simulate the effect of thermal ageing on the performance of a replacement pollution control device until the end of its lifetime.
2.4.2.2.
The engine used for the performance of the service accumulation schedule, fitted with the exhaust after-treatment system incorporating the replacement pollution control device, is operated for a minimum of three consecutive thermal sequences, as set out in Appendix 4.
2.4.2.3.
The temperatures shall be recorded over a minimum of two thermal sequences. The first sequence, conducted for warming up, shall not be taken into account for the purpose of temperature gathering.
2.4.2.4.
The temperatures shall be recorded at suitable locations, chosen in accordance with points 2.2.6 to 2.2.9, at a minimum rate of once every second (1 Hz).
2.4.2.5.
The effective ageing time corresponding to the thermal sequences referred to in point 2.4.2.3, shall be calculated in accordance with the following equations:
Equation 3:
$t_{i}^{e} = \frac{\sum_{n_{c} = 1}^{C} e^{((\frac{R}{T_{r}}) - (\frac{R}{T_{i}}))}}{C}$
Equation 4:
$AE = \sum_{i = 1}^{p} t_{i}^{e}$
Where:
$t_{i}^{e}$
the effective ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device at the temperature T_i during the second i.
T_i
the temperature, in K, measured in the second i, in each one of the thermal sequences.
R
thermal reactivity of the replacement pollution control device. The manufacturer shall agree with the type-approval authority on the R value to be used. It will also be possible, as alternative, to use the following default values:
Diesel oxidation catalyst (DOC): 18 050.
Catalysed DPF: 18 050
SCR or ammonia oxidation catalyst (AMOX) based on iron-zeolite (Fe-Z): 5 175
SCR copper-zeolite (Cu-Z): 11 550
SCR Vanadium (V): 5 175
LNT (lean-NO_x trap): 18 050
T_r
reference temperature, in K, being the same value as in equation 1.
AE
Effective ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device during the duration of the thermal sequence.
AT
total equivalent ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device, over its useful life, to the temperature $T_{i}^{bin}$ during the time $t_{i}^{bin}$ of each one of the i bins registered in the histogram.
i
number of temperature measurement.
p
total number of temperature measurements.
n_c
thermal sequence number, of those conducted for the purpose of temperature gathering, in accordance with point 2.4.2.3.
C
total number of thermal sequences conducted for the purpose of temperature gathering.
2.4.2.6.
The total number of thermal sequences to be included in the service accumulation schedule shall be determined by applying the following equation:
Equation 5:
N_TS = AT/AE
Where:
N_TS
total number of thermal sequences to be carried out during the service accumulation schedule
AT
total equivalent ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device, over its useful life, to the temperature $T_{i}^{bin}$ during the time $t_{i}^{bin}$ of each one of the i bins registered in the histogram.
AE
Effective ageing time, in hours, needed to achieve, by exposing the replacement pollution control device at the temperature T_r, the same amount of ageing as the one that would result from exposure of the replacement pollution control device during the duration of the thermal sequence.
2.4.2.7.
It is allowed to reduce N_TS and, consequently the service accumulation schedule, by increasing the temperatures at which each device is exposed at each mode of the ageing cycle through the application of one or several of the following measures:
(a)
insulating the exhaust pipe;
(b)
moving the replacement pollution control device closer to the exhaust manifold;
(c)
artificially heating up the temperature of the exhaust;
(d)
optimising the engine settings without substantially changing the emission behaviour of the engine.
2.4.2.8.
When applying the measures referred to in points 2.4.4.6 and 2.4.4.7, the total ageing time calculated from N_TS shall not be less than 10 % of the useful life listed in Table 1, e.g. the vehicle category N₁ shall not have an N_TS of less than 286 thermal sequences, assuming that each sequence is 1 hour long.
2.4.2.9.
It is allowed to increase N_TS and, consequently, the duration of the service accumulation schedule, by lowering the temperatures at each mode of the ageing cycle through the application of one or several of the following measures:
(a)
moving the replacement pollution control device further away from the exhaust manifold;
(b)
artificially cooling down the temperature of the exhaust;
(c)
optimising the engine settings.
2.4.2.10.
In the case referred to in point 2.4.1.5, the following shall apply:
2.4.2.10.1.
N_TS shall be the same for each device, so that a single service accumulation schedule can be set up.
2.4.2.10.2.
In order to achieve the same N_TS for each device, a first N_TS value shall be calculated for each device, with its own AT and AE values.
2.4.2.10.3.
If the calculated N_TS values are different, one or more of the measures set out in points 2.4.2.7 to 2.4.2.10 may be applied on the device or devices for which N_TS needs to be modified, over the thermal sequences referred to in point 2.4.2.3, in order to influence the measured T_i and therefore conveniently speed up or slow down the artificial ageing of the targeted device or devices.
2.4.2.10.4.
The new N_TS values corresponding to the new temperatures T_i obtained in point 2.4.2.10.3 shall be calculated.
2.4.2.10.5.
The steps set out in points 2.4.2.10.3 and 2.4.2.10.4 shall be repeated until the N_TS values obtained for each device in the system match.
2.4.2.10.6.
The T_r values used for obtaining the different N_TS in points 2.4.2.10.4 and 2.4.2.10.5 shall be the same ones as those used in points 2.3.2 and 2.3.5 for calculating AT for each device.
2.4.2.11.
In the case of an assembly of replacement pollution control devices constituting a system within the meaning of Article 3(25) of Directive 2007/46/EC, one of the following two options may be considered for the thermal ageing of the devices:
2.4.2.11.1.
The devices within the assembly may be either separately or jointly aged, in accordance with point 2.4.2.10.
2.4.2.11.2.
If the assembly is built in such a way that it is not possible to decouple the devices (e.g. DOC + SCR in a can), the thermal ageing of the assembly shall be carried out with the highest N_TS.
2.4.3.Modified thermal accumulation schedule for devices operating in the presence of active regeneration
2.4.3.1.
The modified thermal accumulation schedule for devices operating in the presence of active regeneration shall simulate the effect of ageing due to both thermal load and active regeneration on a replacement pollution control device at the end of its lifetime.
2.4.3.2.
The engine used for the service accumulation schedule, fitted with the exhaust after-treatment system incorporating the replacement pollution control device, is operated for a minimum of three modified thermal sequences, consisting each sequence of a thermal sequence as set out in Appendix 4, followed by a complete active regeneration, during which the peak temperature reached in the after-treatment system should be not lower than the peak temperature recorded in the data collection phase.
2.4.3.3.
The temperatures shall be recorded over a minimum of two modified thermal sequences. The first sequence, conducted for warming up, shall not be taken into account for the purpose of temperature gathering.
2.4.3.4.
In order to minimise the time elapsed between the thermal sequence as set out in Appendix 4 and the subsequent active regeneration, the manufacturer may artificially trigger the active regeneration by running, after each thermal sequence as set out in Appendix 4, the engine at a steady mode that enables a high production of soot by the engine. In that case, the steady mode shall also be considered as part of the modified thermal sequence set out in point 2.4.3.2.
2.4.3.5.
The effective ageing time corresponding to each modified thermal sequence shall be calculated using equations 3 and 4.
2.4.3.6.
The total number of modified thermal sequences to be conducted during the service accumulation schedule shall be calculated using equation 5.
2.4.3.7.
It is allowed to reduce N_TS, and consequently the duration of the service accumulation schedule, by increasing the temperatures at each mode of the modified thermal sequence, applying one or several of the measures set out in point 2.4.2.7.
2.4.3.8.
In addition to the measures referred to in point 2.4.3.7, N_TS can also be reduced by increasing the peak temperature of the active regeneration within the modified thermal sequence, without exceeding a bed temperature of 800 °C under any circumstances.
2.4.3.9.
N_TS shall never be less than 50 % of the number of active regenerations to which the replacement pollution control device is subjected during its useful life, calculated in accordance with the following equation:
Equation 5:
$N_{AR} = \frac{t_{WHTC}}{t_{AR} + t_{BAR}}$
Where:
N_AR
number of active regeneration sequences over the useful life of the replacement pollution control device.
t_WHTC
equivalent number of hours corresponding to the vehicle category for which the replacement pollution control device is intended, obtained from Table 1.
t_AR
duration, in hours, of an active regeneration.
t_BAR
time, in hours, between two consecutive active regenerations.
2.4.3.10.
If, as consequence of the application of the minimum number of modified thermal sequences as set out in point 2.4.3.9, AE × N_TS calculated using equation 4 exceeds the AT calculated using equation 2, the time of each mode of the thermal sequence set out in Appendix 4, and embedded in the modified thermal sequence as set out in point 2.4.3.2, may be reduced in the same proportion, in order to make AE × N_TS = AT.
2.4.3.11.
It is allowed to increase N_TS and consequently the duration of the service accumulation schedule, by lowering the temperatures at each mode of the thermal-active regeneration sequence by applying one or several of the measures set out in point 2.4.2.9.
2.4.3.12.
In the case referred to in point 2.4.1.5, points 2.4.2.10 and 2.4.2.11 shall apply
2.4.4.Lubricant consumption accumulation schedule
2.4.4.1.
The lubricant consumption accumulation schedule shall simulate the effect of ageing due to chemical poisoning or deposit formation as a result of lubricant consumption, on the performance of a replacement pollution control device at the end of its lifetime.
2.4.4.2.
The lubricant consumed, in g/h, shall be determined over a minimum of 24 thermal sequences or a corresponding number of modified thermal sequences, using any suitable method, as for example the drain and weigh procedure described in Appendix 6. Fresh lubricant shall be used.
2.4.4.3.
The engine shall be equipped with a constant volume oil sump in order to avoid the need of “top-offs”, since oil level influences the oil consumption rate. Any suitable method, as for example the one described in the ASTM standard D7156-09, may be used.
2.4.4.4.
The theoretical time, in hours, that the thermal accumulation schedule or modified thermal accumulation schedule, as it corresponds, would have to be conducted, in order to obtain the same lubricant consumption as the one corresponding to the useful life of the replacement control device, shall be calculated by applying the following equation:
Equation 6:
$t_{TAS} = \frac{{LCR}_{WHTC} \times t_{WHTC}}{{LCR}_{TAS}}$
Where:
t_TAS
theoretical duration, in hours, of the service accumulation schedule required to obtain the same lubricant consumption as the one corresponding to the useful life of the replacement pollution control device, provided that the service accumulation schedule is only made up of a series of consecutive thermal sequences or consecutive modified thermal sequences.
LCR_WHTC
lubricant consumption rate, in g/h determined as set out in point 2.2.15.
t_WHTC
equivalent number of hours corresponding to the vehicle category for which the replacement pollution control device is intended, obtained from Table 1.
LCR_TAS
lubricant consumption rate, in g/h, determined as set out in point 2.4.4.2.
2.4.4.5.
The number of thermal sequences or modified thermal sequences corresponding to t_TAS shall be calculated by applying the following ratio:
Equation 7:
$N = \frac{t_{TAS}}{T_{TS}}$
Where:
N
number of thermal sequences or modified thermal sequences corresponding to t_TAS.
t_TAS
theoretical duration, in hours, of the service accumulation schedule required to obtain the same lubricant consumption as the one corresponding to the useful life of the replacement pollution control device, provided that the service accumulation schedule was only made up of a series of consecutive thermal sequences or consecutive modified thermal sequences.
t_TS
duration, in hours, of a single thermal sequence or modified thermal sequence.
2.4.4.6.
The value of N shall be compared to the value of N_TS calculated in accordance with point 2.4.2.6 or, for devices operating in the presence of active regeneration, in accordance with point 2.4.3.5. If N ≤ N_TS, it is not necessary to add a lubricant consumption accumulation schedule to the thermal accumulation schedule. If N > N_TS, a lubricant consumption accumulation schedule shall be added to the thermal accumulation schedule.
2.4.4.7.
A lubricant consumption accumulation schedule may not have to be added if, by increasing the lubricant consumption as described in point 2.4.4.8.4, the needed lubricant consumption is already achieved with the conduction of the corresponding thermal accumulation schedule consisting of the performance of N_TS thermal sequences or modified thermal sequences.
2.4.4.8.Development of the lubricant consumption accumulation schedule
2.4.4.8.1.
The lubricant consumption accumulation schedule shall consist of a number of lubricant consumption sequences repeated several times, each lubricant consumption sequence being alternated with each thermal sequence or each modified thermal sequence.
2.4.4.8.2.
Each lubricant consumption sequence shall consist of a steady mode at constant load and speed, the load and the speed being selected in such a way that the lubricant consumption is maximised and effective thermal aging is minimised. The mode shall be determined by the manufacturer in agreement with the type-approval authority, based on best engineering judgement.
2.4.4.8.3.
The duration of each lubricant consumption sequence shall be determined as follows:
2.4.4.8.3.1.
The engine shall be run for an appropriate period of time at the load and speed determined by the manufacturer in accordance with point 2.4.4.8.2 and the lubricant consumed, in g/h, shall be determined using any suitable method, as for example the drain and weigh procedure described in Appendix 6. Lubricant changes are to be completed at the recommended intervals.
2.4.4.8.3.2.
The duration of each lubricant consumption sequence shall be calculated by applying the following equation:
Equation 8:
$t_{LS} = \frac{{LCR}_{WHTC} \times t_{WHTC} - {LCR}_{TAS} \times N_{TS} \times t_{TS}}{{LCR}_{LAS} \times N_{TS}}$
Where:
t_LS
the duration, in hours, of a single lubricant consumption sequence
LCR_WHTC
lubricant consumption rate, in g/h determined as set out in point 2.2.15.
t_WHTC
equivalent number of hours corresponding to the vehicle category for which the replacement pollution control device is intended, obtained from Table 1.
LCR_TAS
lubricant consumption rate, in g/h, determined as set out in point 2.4.4.2.
LCR_LAS
lubricant consumption rate, in g/h, determined as set out in point 2.4.4.8.3.1.
t_TS
duration, in hours, of a single thermal sequence, as set out in Appendix 4, or modified thermal sequence, as set out in point 2.4.3.2.
N_TS
total number of thermal sequences or modified thermal sequences to be carried out during the service accumulation schedule.
2.4.4.8.4.
The lubricant consumption rate shall always remain below 0,5 % of the engine fuel consumption rate in order to avoid excessive ash accumulation on the front face of the replacement pollution control device.
2.4.4.8.5.
It is allowed to add the thermal ageing due to the conduction of the lubricant consumption sequence to the AE calculated in equation 4.
2.4.5.Development of the complete service accumulation schedule
2.4.5.1.
The service accumulation schedule shall be built up alternating a thermal or a modified thermal sequence, as appropriate, with a lubricant consumption sequence. The aforementioned pattern shall be repeated N_TS times, being the N_TS value the one calculated either in accordance with Section 2.4.2 or with Section 2.4.3, as appropriate. An example of a complete service accumulation schedule is given in Appendix 7. A flowchart describing the development of a complete service accumulation schedule is given in Appendix 8.
2.4.6.Operation of the service accumulation schedule
2.4.6.1.
The engine, fitted with the exhaust after-treatment system incorporating the replacement pollution control device, shall run the service accumulation schedule set out in point 2.4.5.1.
2.4.6.2.
The engine used for the performance of the service accumulation schedule may be different to the engine used in the data collection phase, being the latter always the one for which the replacement pollution control device to be type-approved has been designed, and the one to be tested for emissions under point 2.4.3.2.
2.4.6.3.
If the engine used for the performance of the service accumulation schedule features a larger displacement by 20 % or more than the engine used in the data collection phase, the exhaust system of the former should be equipped with a by-pass in order to replicate as closely as possible the exhaust flow rate of the latter at the ageing conditions selected.
2.4.6.4.
In the case referred to in point 2.4.6.2, the engine used for the performance of the service accumulation schedule shall be type-approved under Regulation (EC) No 595/2009. In addition, if the device or devices under test are intended for being fitted in an engine system with exhaust gas recirculation (EGR), the engine system used for the service accumulation schedule shall also be fitted with an EGR. If the device or devices under test are intended for not being fitted in an engine system with EGR, the engine system used for the service accumulation schedule shall also not be fitted with an EGR.
2.4.6.5.
The lubricant and the fuel used in the service accumulation schedule shall be as similar as possible to those used during the data collection phase set out in point 2.2. The lubricant must be in line with the recommendation of the engine manufacturer for which the pollution control device is designed. The fuels used should be market fuels fulfilling the corresponding requirements of Directive 98/70/EC. On the request of the manufacturer also reference fuels in accordance with this Regulation can be used.
2.4.6.6.
The lubricant shall be changed for maintenance, at the intervals scheduled by the manufacturer of the engine used in the data collection phase.
2.4.6.7.
In the case of an SCR, the urea injection shall be performed in accordance with the strategy defined by the manufacturer of the replacement pollution control device.’;

Vehicle category	Mileage (km)	Equivalent number of WHTC test-cycles	Equivalent number of hours
Engine systems fitted to vehicles of category M₁, N₁ and N₂	114 286	5 714	2 857
Engine systems fitted to vehicles of category N₂, N₃ with a maximum technically permissible mass not exceeding 16 tonnes and M₃ Class I, Class II and Class A, and Class B with a maximum technically permissible mass exceeding 7,5 tonnes	214 286	10 714	5 357
Engine systems fitted to vehicles of category N₃ with a maximum technically permissible mass exceeding 16 tonnes, and M₃, Class III and Class B with a maximum technically permissible mass exceeding 7,5 tonnes	500 000	25 000	12 500

(5)

the following Appendices 4 to 8 are added:

Appendix 4Sequence for thermal ageing
Mode
Speed (% of high idle)
Load (% for a given speed)
Time (s)
1
2,92
0,58
626
2
45,72
1,58
418
3
38,87
3,37
300
4
20,23
11,36
102
5
11,37
14,90
62
6
32,78
18,52
370
7
53,12
20,19
410
8
59,53
34,73
780
9
78,24
54,38
132
10
39,07
62,85
212
11
47,82
62,94
188
Regeneration mode (if applicable)
To be defined (see point 2.4.3.4)
To be defined (see point 2.4.3.4)
To be defined (see point 2.4.3.4)
Lubricant consumption mode (if applicable)
To be defined according to point 2.4.4.8.2
To be defined according to point 2.4.4.8.2
To be defined according to point 2.4.4.8.3
Note:
The sequence of the modes 1 to 11 has been arranged by ascending load in order to maximise the temperature of the exhaust gas in the high load modes. With the agreement of the type-approval authority, this order can be modified in order to optimise the temperature of the exhaust gas if this can help in reducing the actual aging time.
Appendix 5Test-cycle for chassis dynamometer or on-road data gathering
Time
Speed
Time
Speed
Time
Speed
Time
Speed
Time
Speed
Time
Speed
Time
Speed
s
km/h
s
km/h
s
km/h
s
km/h
s
km/h
s
km/h
s
km/h
1
0
261
22,38
521
35,46
781
18,33
1 041
39,88
1 301
66,39
1 561
86,88
2
0
262
24,75
522
36,81
782
18,31
1 042
41,25
1 302
66,74
1 562
86,7
3
0
263
25,55
523
37,98
783
18,05
1 043
42,07
1 303
67,43
1 563
86,81
4
0
264
25,18
524
38,84
784
17,39
1 044
43,03
1 304
68,44
1 564
86,81
5
0
265
23,94
525
39,43
785
16,35
1 045
44,4
1 305
69,52
1 565
86,81
6
0
266
22,35
526
39,73
786
14,71
1 046
45,14
1 306
70,53
1 566
86,81
7
2,35
267
21,28
527
39,8
787
11,71
1 047
45,44
1 307
71,47
1 567
86,99
8
5,57
268
20,86
528
39,69
788
7,81
1 048
46,13
1 308
72,32
1 568
87,03
9
8,18
269
20,65
529
39,29
789
5,25
1 049
46,79
1 309
72,89
1 569
86,92
10
9,37
270
20,18
530
38,59
790
4,62
1 050
47,45
1 310
73,07
1 570
87,1
11
9,86
271
19,33
531
37,63
791
5,62
1 051
48,68
1 311
73,03
1 571
86,85
12
10,18
272
18,23
532
36,22
792
8,24
1 052
50,13
1 312
72,94
1 572
87,14
13
10,38
273
16,99
533
34,11
793
10,98
1 053
51,16
1 313
73,01
1 573
86,96
14
10,57
274
15,56
534
31,16
794
13,15
1 054
51,37
1 314
73,44
1 574
86,85
15
10,95
275
13,76
535
27,49
795
15,47
1 055
51,3
1 315
74,19
1 575
86,77
16
11,56
276
11,5
536
23,63
796
18,19
1 056
51,15
1 316
74,81
1 576
86,81
17
12,22
277
8,68
537
20,16
797
20,79
1 057
50,88
1 317
75,01
1 577
86,85
18
12,97
278
5,2
538
17,27
798
22,5
1 058
50,63
1 318
74,99
1 578
86,74
19
14,33
279
1,99
539
14,81
799
23,19
1 059
50,2
1 319
74,79
1 579
86,81
20
16,38
280
0
540
12,59
800
23,54
1 060
49,12
1 320
74,41
1 580
86,7
21
18,4
281
0
541
10,47
801
24,2
1 061
48,02
1 321
74,07
1 581
86,52
22
19,86
282
0
542
8,85
802
25,17
1 062
47,7
1 322
73,77
1 582
86,7
23
20,85
283
0,5
543
8,16
803
26,28
1 063
47,93
1 323
73,38
1 583
86,74
24
21,52
284
0,57
544
8,95
804
27,69
1 064
48,57
1 324
72,79
1 584
86,81
25
21,89
285
0,6
545
11,3
805
29,72
1 065
48,88
1 325
71,95
1 585
86,85
26
21,98
286
0,58
546
14,11
806
32,17
1 066
49,03
1 326
71,06
1 586
86,92
27
21,91
287
0
547
15,91
807
34,22
1 067
48,94
1 327
70,45
1 587
86,88
28
21,68
288
0
548
16,57
808
35,31
1 068
48,32
1 328
70,23
1 588
86,85
29
21,21
289
0
549
16,73
809
35,74
1 069
47,97
1 329
70,24
1 589
87,1
30
20,44
290
0
550
17,24
810
36,23
1 070
47,92
1 330
70,32
1 590
86,81
31
19,24
291
0
551
18,45
811
37,34
1 071
47,54
1 331
70,3
1 591
86,99
32
17,57
292
0
552
20,09
812
39,05
1 072
46,79
1 332
70,05
1 592
86,81
33
15,53
293
0
553
21,63
813
40,76
1 073
46,13
1 333
69,66
1 593
87,14
34
13,77
294
0
554
22,78
814
41,82
1 074
45,73
1 334
69,26
1 594
86,81
35
12,95
295
0
555
23,59
815
42,12
1 075
45,17
1 335
68,73
1 595
86,85
36
12,95
296
0
556
24,23
816
42,08
1 076
44,43
1 336
67,88
1 596
87,03
37
13,35
297
0
557
24,9
817
42,27
1 077
43,59
1 337
66,68
1 597
86,92
38
13,75
298
0
558
25,72
818
43,03
1 078
42,68
1 338
65,29
1 598
87,14
39
13,82
299
0
559
26,77
819
44,14
1 079
41,89
1 339
63,95
1 599
86,92
40
13,41
300
0
560
28,01
820
45,13
1 080
41,09
1 340
62,84
1 600
87,03
41
12,26
301
0
561
29,23
821
45,84
1 081
40,38
1 341
62,21
1 601
86,99
42
9,82
302
0
562
30,06
822
46,4
1 082
39,99
1 342
62,04
1 602
86,96
43
5,96
303
0
563
30,31
823
46,89
1 083
39,84
1 343
62,26
1 603
87,03
44
2,2
304
0
564
30,29
824
47,34
1 084
39,46
1 344
62,87
1 604
86,85
45
0
305
0
565
30,05
825
47,66
1 085
39,15
1 345
63,55
1 605
87,1
46
0
306
0
566
29,44
826
47,77
1 086
38,9
1 346
64,12
1 606
86,81
47
0
307
0
567
28,6
827
47,78
1 087
38,67
1 347
64,73
1 607
87,03
48
0
308
0
568
27,63
828
47,64
1 088
39,03
1 348
65,45
1 608
86,77
49
0
309
0
569
26,66
829
47,23
1 089
40,37
1 349
66,18
1 609
86,99
50
1,87
310
0
570
26,03
830
46,66
1 090
41,03
1 350
66,97
1 610
86,96
51
4,97
311
0
571
25,85
831
46,08
1 091
40,76
1 351
67,85
1 611
86,96
52
8,4
312
0
572
26,14
832
45,45
1 092
40,02
1 352
68,74
1 612
87,07
53
9,9
313
0
573
27,08
833
44,69
1 093
39,6
1 353
69,45
1 613
86,96
54
11,42
314
0
574
28,42
834
43,73
1 094
39,37
1 354
69,92
1 614
86,92
55
15,11
315
0
575
29,61
835
42,55
1 095
38,84
1 355
70,24
1 615
87,07
56
18,46
316
0
576
30,46
836
41,14
1 096
37,93
1 356
70,49
1 616
86,92
57
20,21
317
0
577
30,99
837
39,56
1 097
37,19
1 357
70,63
1 617
87,14
58
22,13
318
0
578
31,33
838
37,93
1 098
36,21
1 358
70,68
1 618
86,96
59
24,17
319
0
579
31,65
839
36,69
1 099
35,32
1 359
70,65
1 619
87,03
60
25,56
320
0
580
32,02
840
36,27
1 100
35,56
1 360
70,49
1 620
86,85
61
26,97
321
0
581
32,39
841
36,42
1 101
36,96
1 361
70,09
1 621
86,77
62
28,83
322
0
582
32,68
842
37,14
1 102
38,12
1 362
69,35
1 622
87,1
63
31,05
323
0
583
32,84
843
38,13
1 103
38,71
1 363
68,27
1 623
86,92
64
33,72
324
3,01
584
32,93
844
38,55
1 104
39,26
1 364
67,09
1 624
87,07
65
36
325
8,14
585
33,22
845
38,42
1 105
40,64
1 365
65,96
1 625
86,85
66
37,91
326
13,88
586
33,89
846
37,89
1 106
43,09
1 366
64,87
1 626
86,81
67
39,65
327
18,08
587
34,96
847
36,89
1 107
44,83
1 367
63,79
1 627
87,14
68
41,23
328
20,01
588
36,28
848
35,53
1 108
45,33
1 368
62,82
1 628
86,77
69
42,85
329
20,3
589
37,58
849
34,01
1 109
45,24
1 369
63,03
1 629
87,03
70
44,1
330
19,53
590
38,58
850
32,88
1 110
45,14
1 370
63,62
1 630
86,96
71
44,37
331
17,92
591
39,1
851
32,52
1 111
45,06
1 371
64,8
1 631
87,1
72
44,3
332
16,17
592
39,22
852
32,7
1 112
44,82
1 372
65,5
1 632
86,99
73
44,17
333
14,55
593
39,11
853
33,48
1 113
44,53
1 373
65,33
1 633
86,92
74
44,13
334
12,92
594
38,8
854
34,97
1 114
44,77
1 374
63,83
1 634
87,1
75
44,17
335
11,07
595
38,31
855
36,78
1 115
45,6
1 375
62,44
1 635
86,85
76
44,51
336
8,54
596
37,73
856
38,64
1 116
46,28
1 376
61,2
1 636
86,92
77
45,16
337
5,15
597
37,24
857
40,48
1 117
47,18
1 377
59,58
1 637
86,77
78
45,64
338
1,96
598
37,06
858
42,34
1 118
48,49
1 378
57,68
1 638
86,88
79
46,16
339
0
599
37,1
859
44,16
1 119
49,42
1 379
56,4
1 639
86,63
80
46,99
340
0
600
37,42
860
45,9
1 120
49,56
1 380
54,82
1 640
86,85
81
48,19
341
0
601
38,17
861
47,55
1 121
49,47
1 381
52,77
1 641
86,63
82
49,32
342
0
602
39,19
862
49,09
1 122
49,28
1 382
52,22
1 642
86,77
83
49,7
343
0
603
40,31
863
50,42
1 123
48,58
1 383
52,48
1 643
86,77
84
49,5
344
0
604
41,46
864
51,49
1 124
48,03
1 384
52,74
1 644
86,55
85
48,98
345
0
605
42,44
865
52,23
1 125
48,2
1 385
53,14
1 645
86,59
86
48,65
346
0
606
42,95
866
52,58
1 126
48,72
1 386
53,03
1 646
86,55
87
48,65
347
0
607
42,9
867
52,63
1 127
48,91
1 387
52,55
1 647
86,7
88
48,87
348
0
608
42,43
868
52,49
1 128
48,93
1 388
52,19
1 648
86,44
89
48,97
349
0
609
41,74
869
52,19
1 129
49,05
1 389
51,09
1 649
86,7
90
48,96
350
0
610
41,04
870
51,82
1 130
49,23
1 390
49,88
1 650
86,55
91
49,15
351
0
611
40,49
871
51,43
1 131
49,28
1 391
49,37
1 651
86,33
92
49,51
352
0
612
40,8
872
51,02
1 132
48,84
1 392
49,26
1 652
86,48
93
49,74
353
0
613
41,66
873
50,61
1 133
48,12
1 393
49,37
1 653
86,19
94
50,31
354
0,9
614
42,48
874
50,26
1 134
47,8
1 394
49,88
1 654
86,37
95
50,78
355
2
615
42,78
875
50,06
1 135
47,42
1 395
50,25
1 655
86,59
96
50,75
356
4,08
616
42,39
876
49,97
1 136
45,98
1 396
50,17
1 656
86,55
97
50,78
357
7,07
617
40,78
877
49,67
1 137
42,96
1 397
50,5
1 657
86,7
98
51,21
358
10,25
618
37,72
878
48,86
1 138
39,38
1 398
50,83
1 658
86,63
99
51,6
359
12,77
619
33,29
879
47,53
1 139
35,82
1 399
51,23
1 659
86,55
100
51,89
360
14,44
620
27,66
880
45,82
1 140
31,85
1 400
51,67
1 660
86,59
101
52,04
361
15,73
621
21,43
881
43,66
1 141
26,87
1 401
51,53
1 661
86,55
102
51,99
362
17,23
622
15,62
882
40,91
1 142
21,41
1 402
50,17
1 662
86,7
103
51,99
363
19,04
623
11,51
883
37,78
1 143
16,41
1 403
49,99
1 663
86,55
104
52,36
364
20,96
624
9,69
884
34,89
1 144
12,56
1 404
50,32
1 664
86,7
105
52,58
365
22,94
625
9,46
885
32,69
1 145
10,41
1 405
51,05
1 665
86,52
106
52,47
366
25,05
626
10,21
886
30,99
1 146
9,07
1 406
51,45
1 666
86,85
107
52,03
367
27,31
627
11,78
887
29,31
1 147
7,69
1 407
52
1 667
86,55
108
51,46
368
29,54
628
13,6
888
27,29
1 148
6,28
1 408
52,3
1 668
86,81
109
51,31
369
31,52
629
15,33
889
24,79
1 149
5,08
1 409
52,22
1 669
86,74
110
51,45
370
33,19
630
17,12
890
21,78
1 150
4,32
1 410
52,66
1 670
86,63
111
51,48
371
34,67
631
18,98
891
18,51
1 151
3,32
1 411
53,18
1 671
86,77
112
51,29
372
36,13
632
20,73
892
15,1
1 152
1,92
1 412
53,8
1 672
87,03
113
51,12
373
37,63
633
22,17
893
11,06
1 153
1,07
1 413
54,53
1 673
87,07
114
50,96
374
39,07
634
23,29
894
6,28
1 154
0,66
1 414
55,37
1 674
86,92
115
50,81
375
40,08
635
24,19
895
2,24
1 155
0
1 415
56,29
1 675
87,07
116
50,86
376
40,44
636
24,97
896
0
1 156
0
1 416
57,31
1 676
87,18
117
51,34
377
40,26
637
25,6
897
0
1 157
0
1 417
57,94
1 677
87,32
118
51,68
378
39,29
638
25,96
898
0
1 158
0
1 418
57,86
1 678
87,36
119
51,58
379
37,23
639
25,86
899
0
1 159
0
1 419
57,75
1 679
87,29
120
51,36
380
34,14
640
24,69
900
0
1 160
0
1 420
58,67
1 680
87,58
121
51,39
381
30,18
641
21,85
901
0
1 161
0
1 421
59,4
1 681
87,61
122
50,98
382
25,71
642
17,45
902
2,56
1 162
0
1 422
59,69
1 682
87,76
123
48,63
383
21,58
643
12,34
903
4,81
1 163
0
1 423
60,02
1 683
87,65
124
44,83
384
18,5
644
7,59
904
6,38
1 164
0
1 424
60,21
1 684
87,61
125
40,3
385
16,56
645
4
905
8,62
1 165
0
1 425
60,83
1 685
87,65
126
35,65
386
15,39
646
1,76
906
10,37
1 166
0
1 426
61,16
1 686
87,65
127
30,23
387
14,77
647
0
907
11,17
1 167
0
1 427
61,6
1 687
87,76
128
24,08
388
14,58
648
0
908
13,32
1 168
0
1 428
62,15
1 688
87,76
129
18,96
389
14,72
649
0
909
15,94
1 169
0
1 429
62,7
1 689
87,8
130
14,19
390
15,44
650
0
910
16,89
1 170
0
1 430
63,65
1 690
87,72
131
8,72
391
16,92
651
0
911
17,13
1 171
0
1 431
64,27
1 691
87,69
132
3,41
392
18,69
652
0
912
18,04
1 172
0
1 432
64,31
1 692
87,54
133
0,64
393
20,26
653
0
913
19,96
1 173
0
1 433
64,13
1 693
87,76
134
0
394
21,63
654
0
914
22,05
1 174
0
1 434
64,27
1 694
87,5
135
0
395
22,91
655
0
915
23,65
1 175
0
1 435
65,22
1 695
87,43
136
0
396
24,13
656
0
916
25,72
1 176
0
1 436
66,25
1 696
87,47
137
0
397
25,18
657
0
917
28,62
1 177
0
1 437
67,09
1 697
87,5
138
0
398
26,16
658
2,96
918
31,99
1 178
0
1 438
68,37
1 698
87,5
139
0
399
27,41
659
7,9
919
35,07
1 179
0
1 439
69,36
1 699
87,18
140
0
400
29,18
660
13,49
920
37,42
1 180
0
1 440
70,57
1 700
87,36
141
0
401
31,36
661
18,36
921
39,65
1 181
0
1 441
71,89
1 701
87,29
142
0,63
402
33,51
662
22,59
922
41,78
1 182
0
1 442
73,35
1 702
87,18
143
1,56
403
35,33
663
26,26
923
43,04
1 183
0
1 443
74,64
1 703
86,92
144
2,99
404
36,94
664
29,4
924
43,55
1 184
0
1 444
75,81
1 704
87,36
145
4,5
405
38,6
665
32,23
925
42,97
1 185
0
1 445
77,24
1 705
87,03
146
5,39
406
40,44
666
34,91
926
41,08
1 186
0
1 446
78,63
1 706
87,07
147
5,59
407
42,29
667
37,39
927
40,38
1 187
0
1 447
79,32
1 707
87,29
148
5,45
408
43,73
668
39,61
928
40,43
1 188
0
1 448
80,2
1 708
86,99
149
5,2
409
44,47
669
41,61
929
40,4
1 189
0
1 449
81,67
1 709
87,25
150
4,98
410
44,62
670
43,51
930
40,25
1 190
0
1 450
82,11
1 710
87,14
151
4,61
411
44,41
671
45,36
931
40,32
1 191
0
1 451
82,91
1 711
86,96
152
3,89
412
43,96
672
47,17
932
40,8
1 192
0
1 452
83,43
1 712
87,14
153
3,21
413
43,41
673
48,95
933
41,71
1 193
0
1 453
83,79
1 713
87,07
154
2,98
414
42,83
674
50,73
934
43,16
1 194
0
1 454
83,5
1 714
86,92
155
3,31
415
42,15
675
52,36
935
44,84
1 195
0
1 455
84,01
1 715
86,88
156
4,18
416
41,28
676
53,74
936
46,42
1 196
1,54
1 456
83,43
1 716
86,85
157
5,07
417
40,17
677
55,02
937
47,91
1 197
4,85
1 457
82,99
1 717
86,92
158
5,52
418
38,9
678
56,24
938
49,08
1 198
9,06
1 458
82,77
1 718
86,81
159
5,73
419
37,59
679
57,29
939
49,66
1 199
11,8
1 459
82,33
1 719
86,88
160
6,06
420
36,39
680
58,18
940
50,15
1 200
12,42
1 460
81,78
1 720
86,66
161
6,76
421
35,33
681
58,95
941
50,94
1 201
12,07
1 461
81,81
1 721
86,92
162
7,7
422
34,3
682
59,49
942
51,69
1 202
11,64
1 462
81,05
1 722
86,48
163
8,34
423
33,07
683
59,86
943
53,5
1 203
11,69
1 463
80,72
1 723
86,66
164
8,51
424
31,41
684
60,3
944
55,9
1 204
12,91
1 464
80,61
1 724
86,74
165
8,22
425
29,18
685
61,01
945
57,11
1 205
15,58
1 465
80,46
1 725
86,37
166
7,22
426
26,41
686
61,96
946
57,88
1 206
18,69
1 466
80,42
1 726
86,48
167
5,82
427
23,4
687
63,05
947
58,63
1 207
21,04
1 467
80,42
1 727
86,33
168
4,75
428
20,9
688
64,16
948
58,75
1 208
22,62
1 468
80,24
1 728
86,3
169
4,24
429
19,59
689
65,14
949
58,26
1 209
24,34
1 469
80,13
1 729
86,44
170
4,05
430
19,36
690
65,85
950
58,03
1 210
26,74
1 470
80,39
1 730
86,33
171
3,98
431
19,79
691
66,22
951
58,28
1 211
29,62
1 471
80,72
1 731
86
172
3,91
432
20,43
692
66,12
952
58,67
1 212
32,65
1 472
81,01
1 732
86,33
173
3,86
433
20,71
693
65,01
953
58,76
1 213
35,57
1 473
81,52
1 733
86,22
174
4,17
434
20,56
694
62,22
954
58,82
1 214
38,07
1 474
82,4
1 734
86,08
175
5,32
435
19,96
695
57,44
955
59,09
1 215
39,71
1 475
83,21
1 735
86,22
176
7,53
436
20,22
696
51,47
956
59,38
1 216
40,36
1 476
84,05
1 736
86,33
177
10,89
437
21,48
697
45,98
957
59,72
1 217
40,6
1 477
84,85
1 737
86,33
178
14,81
438
23,67
698
41,72
958
60,04
1 218
41,15
1 478
85,42
1 738
86,26
179
17,56
439
26,09
699
38,22
959
60,13
1 219
42,23
1 479
86,18
1 739
86,48
180
18,38
440
28,16
700
34,65
960
59,33
1 220
43,61
1 480
86,45
1 740
86,48
181
17,49
441
29,75
701
30,65
961
58,52
1 221
45,08
1 481
86,64
1 741
86,55
182
15,18
442
30,97
702
26,46
962
57,82
1 222
46,58
1 482
86,57
1 742
86,66
183
13,08
443
31,99
703
22,32
963
56,68
1 223
48,13
1 483
86,43
1 743
86,66
184
12,23
444
32,84
704
18,15
964
55,36
1 224
49,7
1 484
86,58
1 744
86,59
185
12,03
445
33,33
705
13,79
965
54,63
1 225
51,27
1 485
86,8
1 745
86,55
186
11,72
446
33,45
706
9,29
966
54,04
1 226
52,8
1 486
86,65
1 746
86,74
187
10,69
447
33,27
707
4,98
967
53,15
1 227
54,3
1 487
86,14
1 747
86,21
188
8,68
448
32,66
708
1,71
968
52,02
1 228
55,8
1 488
86,36
1 748
85,96
189
6,2
449
31,73
709
0
969
51,37
1 229
57,29
1 489
86,32
1 749
85,5
190
4,07
450
30,58
710
0
970
51,41
1 230
58,73
1 490
86,25
1 750
84,77
191
2,65
451
29,2
711
0
971
52,2
1 231
60,12
1 491
85,92
1 751
84,65
192
1,92
452
27,56
712
0
972
53,52
1 232
61,5
1 492
86,14
1 752
84,1
193
1,69
453
25,71
713
0
973
54,34
1 233
62,94
1 493
86,36
1 753
83,46
194
1,68
454
23,76
714
0
974
54,59
1 234
64,39
1 494
86,25
1 754
82,77
195
1,66
455
21,87
715
0
975
54,92
1 235
65,52
1 495
86,5
1 755
81,78
196
1,53
456
20,15
716
0
976
55,69
1 236
66,07
1 496
86,14
1 756
81,16
197
1,3
457
18,38
717
0
977
56,51
1 237
66,19
1 497
86,29
1 757
80,42
198
1
458
15,93
718
0
978
56,73
1 238
66,19
1 498
86,4
1 758
79,21
199
0,77
459
12,33
719
0
979
56,33
1 239
66,43
1 499
86,36
1 759
78,48
200
0,63
460
7,99
720
0
980
55,38
1 240
67,07
1 500
85,63
1 760
77,49
201
0,59
461
4,19
721
0
981
54,99
1 241
68,04
1 501
86,03
1 761
76,69
202
0,59
462
1,77
722
0
982
54,75
1 242
69,12
1 502
85,92
1 762
75,92
203
0,57
463
0,69
723
0
983
54,11
1 243
70,08
1 503
86,14
1 763
75,08
204
0,53
464
1,13
724
0
984
53,32
1 244
70,91
1 504
86,32
1 764
73,87
205
0,5
465
2,2
725
0
985
52,41
1 245
71,73
1 505
85,92
1 765
72,15
206
0
466
3,59
726
0
986
51,45
1 246
72,66
1 506
86,11
1 766
69,69
207
0
467
4,88
727
0
987
50,86
1 247
73,67
1 507
85,91
1 767
67,17
208
0
468
5,85
728
0
988
50,48
1 248
74,55
1 508
85,83
1 768
64,75
209
0
469
6,72
729
0
989
49,6
1 249
75,18
1 509
85,86
1 769
62,55
210
0
470
8,02
730
0
990
48,55
1 250
75,59
1 510
85,5
1 770
60,32
211
0
471
10,02
731
0
991
47,87
1 251
75,82
1 511
84,97
1 771
58,45
212
0
472
12,59
732
0
992
47,42
1 252
75,9
1 512
84,8
1 772
56,43
213
0
473
15,43
733
0
993
46,86
1 253
75,92
1 513
84,2
1 773
54,35
214
0
474
18,32
734
0
994
46,08
1 254
75,87
1 514
83,26
1 774
52,22
215
0
475
21,19
735
0
995
45,07
1 255
75,68
1 515
82,77
1 775
50,25
216
0
476
24
736
0
996
43,58
1 256
75,37
1 516
81,78
1 776
48,23
217
0
477
26,75
737
0
997
41,04
1 257
75,01
1 517
81,16
1 777
46,51
218
0
478
29,53
738
0
998
38,39
1 258
74,55
1 518
80,42
1 778
44,35
219
0
479
32,31
739
0
999
35,69
1 259
73,8
1 519
79,21
1 779
41,97
220
0
480
34,8
740
0
1 000
32,68
1 260
72,71
1 520
78,83
1 780
39,33
221
0
481
36,73
741
0
1 001
29,82
1 261
71,39
1 521
78,52
1 781
36,48
222
0
482
38,08
742
0
1 002
26,97
1 262
70,02
1 522
78,52
1 782
33,8
223
0
483
39,11
743
0
1 003
24,03
1 263
68,71
1 523
78,81
1 783
31,09
224
0
484
40,16
744
0
1 004
21,67
1 264
67,52
1 524
79,26
1 784
28,24
225
0
485
41,18
745
0
1 005
20,34
1 265
66,44
1 525
79,61
1 785
26,81
226
0,73
486
41,75
746
0
1 006
18,9
1 266
65,45
1 526
80,15
1 786
23,33
227
0,73
487
41,87
747
0
1 007
16,21
1 267
64,49
1 527
80,39
1 787
19,01
228
0
488
41,43
748
0
1 008
13,84
1 268
63,54
1 528
80,72
1 788
15,05
229
0
489
39,99
749
0
1 009
12,25
1 269
62,6
1 529
81,01
1 789
12,09
230
0
490
37,71
750
0
1 010
10,4
1 270
61,67
1 530
81,52
1 790
9,49
231
0
491
34,93
751
0
1 011
7,94
1 271
60,69
1 531
82,4
1 791
6,81
232
0
492
31,79
752
0
1 012
6,05
1 272
59,64
1 532
83,21
1 792
4,28
233
0
493
28,65
753
0
1 013
5,67
1 273
58,6
1 533
84,05
1 793
2,09
234
0
494
25,92
754
0
1 014
6,03
1 274
57,64
1 534
85,15
1 794
0,88
235
0
495
23,91
755
0
1 015
7,68
1 275
56,79
1 535
85,92
1 795
0,88
236
0
496
22,81
756
0
1 016
10,97
1 276
55,95
1 536
86,98
1 796
0
237
0
497
22,53
757
0
1 017
14,72
1 277
55,09
1 537
87,45
1 797
0
238
0
498
22,62
758
0
1 018
17,32
1 278
54,2
1 538
87,54
1 798
0
239
0
499
22,95
759
0
1 019
18,59
1 279
53,33
1 539
87,25
1 799
0
240
0
500
23,51
760
0
1 020
19,35
1 280
52,52
1 540
87,04
1 800
0
241
0
501
24,04
761
0
1 021
20,54
1 281
51,75
1 541
86,98
242
0
502
24,45
762
0
1 022
21,33
1 282
50,92
1 542
87,05
243
0
503
24,81
763
0
1 023
22,06
1 283
49,9
1 543
87,1
244
0
504
25,29
764
0
1 024
23,39
1 284
48,68
1 544
87,25
245
0
505
25,99
765
0
1 025
25,52
1 285
47,41
1 545
87,25
246
0
506
26,83
766
0
1 026
28,28
1 286
46,5
1 546
87,07
247
0
507
27,6
767
0
1 027
30,38
1 287
46,22
1 547
87,29
248
0
508
28,17
768
0
1 028
31,22
1 288
46,44
1 548
87,14
249
0
509
28,63
769
0
1 029
32,22
1 289
47,35
1 549
87,03
250
0
510
29,04
770
0
1 030
33,78
1 290
49,01
1 550
87,25
251
0
511
29,43
771
0
1 031
35,08
1 291
50,93
1 551
87,03
252
0
512
29,78
772
1,6
1 032
35,91
1 292
52,79
1 552
87,03
253
1,51
513
30,13
773
5,03
1 033
36,06
1 293
54,66
1 553
87,07
254
4,12
514
30,57
774
9,49
1 034
35,5
1 294
56,6
1 554
86,81
255
7,02
515
31,1
775
13
1 035
34,76
1 295
58,55
1 555
86,92
256
9,45
516
31,65
776
14,65
1 036
34,7
1 296
60,47
1 556
86,66
257
11,86
517
32,14
777
15,15
1 037
35,41
1 297
62,28
1 557
86,92
258
14,52
518
32,62
778
15,67
1 038
36,65
1 298
63,9
1 558
86,59
259
17,01
519
33,25
779
16,76
1 039
37,57
1 299
65,2
1 559
86,92
260
19,48
520
34,2
780
17,88
1 040
38,51
1 300
66,02
1 560
86,59
Appendix 6Drain and weigh procedure
1.
The engine shall be filled with new oil. If a constant volume oil sump system (as described in ASTM standard D7156-09) is used, the oil pump shall be turned on while filling the engine. Enough oil charge shall be added to fill up both the engine and external sump.
2.
The engine shall be started and operated over the desired test cycle (see points 2.2.15 and 2.4.4.8.3.1) for a minimum of 1 hour.
3.
Once the cycle is complete, oil temperature shall be allowed to stabilise at a steady-state engine condition before shutting the engine down.
4.
A clean, empty oil drain pan shall be weighed.
5.
Any clean supplies that are to be used during the oil drain (e.g. rags) shall be weighed.
6.
The oil shall be drained for 10 minutes with the external oil pump (if equipped) powered on followed by an additional ten minutes with the pump powered off. If a constant volume sump system is not used, the oil shall be drained from the engine for a total of 20 minutes.
7.
The drained oil shall be weighed.
8.
The weight determined in accordance with step 7 shall be subtracted from the weight determined in accordance with step 4. The difference corresponds to the total weight of the oil removed from the engine and collected in the drain pan.
9.
The oil shall be carefully returned to the engine.
10.
The empty drain pan shall be weighted.
11.
The weight determined in accordance with step 10 shall be subtracted from the weight determined in accordance with step 4. The result corresponds to the weight of the residual oil in the drain pan that was not returned to the engine.
12.
Any dirty supplies which have previously been weighed pursuant to step 5 shall be weighed.
13.
The weight determined in accordance with step 12 shall be subtracted from the weight determined in accordance with step 5. The result corresponds to the weight of the residual oil which remained on the dirty supplies that was not returned to the engine.
14.
The residual oil weights calculated in accordance with steps 11 and 13 shall be subtracted from the total weight of the oil removed, calculated in accordance with step 8. The difference between those weights corresponds to the total weight of the oil returned to the engine.
15.
The engine shall be operated under the desired test cycle(s) (see points 2.2.15 and 2.4.4.8.3.1).
16.
Steps 3-8 shall be repeated.
17.
The weight of the oil drained pursuant to step 16 shall be subtracted from the weight obtained in accordance with step 14. The difference between those weights corresponds to the total weight of the oil consumed.
18.
The total weight of the oil consumed calculated pursuant to step 14 shall be divided by the duration, in hours, of the test cycles carried out in accordance with step 15. The result is the lubricant consumption rate.
Appendix 7Example of service accumulation schedule including thermal, lubricant consumption and regeneration sequences
Appendix 8Flowchart on the performance of the service accumulation schedule

Mode	Speed (% of high idle)	Load (% for a given speed)	Time (s)
1	2,92	0,58	626
2	45,72	1,58	418
3	38,87	3,37	300
4	20,23	11,36	102
5	11,37	14,90	62
6	32,78	18,52	370
7	53,12	20,19	410
8	59,53	34,73	780
9	78,24	54,38	132
10	39,07	62,85	212
11	47,82	62,94	188
Regeneration mode (if applicable)	To be defined (see point 2.4.3.4)	To be defined (see point 2.4.3.4)	To be defined (see point 2.4.3.4)
Lubricant consumption mode (if applicable)	To be defined according to point 2.4.4.8.2	To be defined according to point 2.4.4.8.2	To be defined according to point 2.4.4.8.3

Time	Speed	Time	Speed	Time	Speed	Time	Speed	Time	Speed	Time	Speed	Time	Speed
s	km/h	s	km/h	s	km/h	s	km/h	s	km/h	s	km/h	s	km/h
1	0	261	22,38	521	35,46	781	18,33	1 041	39,88	1 301	66,39	1 561	86,88
2	0	262	24,75	522	36,81	782	18,31	1 042	41,25	1 302	66,74	1 562	86,7
3	0	263	25,55	523	37,98	783	18,05	1 043	42,07	1 303	67,43	1 563	86,81
4	0	264	25,18	524	38,84	784	17,39	1 044	43,03	1 304	68,44	1 564	86,81
5	0	265	23,94	525	39,43	785	16,35	1 045	44,4	1 305	69,52	1 565	86,81
6	0	266	22,35	526	39,73	786	14,71	1 046	45,14	1 306	70,53	1 566	86,81
7	2,35	267	21,28	527	39,8	787	11,71	1 047	45,44	1 307	71,47	1 567	86,99
8	5,57	268	20,86	528	39,69	788	7,81	1 048	46,13	1 308	72,32	1 568	87,03
9	8,18	269	20,65	529	39,29	789	5,25	1 049	46,79	1 309	72,89	1 569	86,92
10	9,37	270	20,18	530	38,59	790	4,62	1 050	47,45	1 310	73,07	1 570	87,1
11	9,86	271	19,33	531	37,63	791	5,62	1 051	48,68	1 311	73,03	1 571	86,85
12	10,18	272	18,23	532	36,22	792	8,24	1 052	50,13	1 312	72,94	1 572	87,14
13	10,38	273	16,99	533	34,11	793	10,98	1 053	51,16	1 313	73,01	1 573	86,96
14	10,57	274	15,56	534	31,16	794	13,15	1 054	51,37	1 314	73,44	1 574	86,85
15	10,95	275	13,76	535	27,49	795	15,47	1 055	51,3	1 315	74,19	1 575	86,77
16	11,56	276	11,5	536	23,63	796	18,19	1 056	51,15	1 316	74,81	1 576	86,81
17	12,22	277	8,68	537	20,16	797	20,79	1 057	50,88	1 317	75,01	1 577	86,85
18	12,97	278	5,2	538	17,27	798	22,5	1 058	50,63	1 318	74,99	1 578	86,74
19	14,33	279	1,99	539	14,81	799	23,19	1 059	50,2	1 319	74,79	1 579	86,81
20	16,38	280	0	540	12,59	800	23,54	1 060	49,12	1 320	74,41	1 580	86,7
21	18,4	281	0	541	10,47	801	24,2	1 061	48,02	1 321	74,07	1 581	86,52
22	19,86	282	0	542	8,85	802	25,17	1 062	47,7	1 322	73,77	1 582	86,7
23	20,85	283	0,5	543	8,16	803	26,28	1 063	47,93	1 323	73,38	1 583	86,74
24	21,52	284	0,57	544	8,95	804	27,69	1 064	48,57	1 324	72,79	1 584	86,81
25	21,89	285	0,6	545	11,3	805	29,72	1 065	48,88	1 325	71,95	1 585	86,85
26	21,98	286	0,58	546	14,11	806	32,17	1 066	49,03	1 326	71,06	1 586	86,92
27	21,91	287	0	547	15,91	807	34,22	1 067	48,94	1 327	70,45	1 587	86,88
28	21,68	288	0	548	16,57	808	35,31	1 068	48,32	1 328	70,23	1 588	86,85
29	21,21	289	0	549	16,73	809	35,74	1 069	47,97	1 329	70,24	1 589	87,1
30	20,44	290	0	550	17,24	810	36,23	1 070	47,92	1 330	70,32	1 590	86,81
31	19,24	291	0	551	18,45	811	37,34	1 071	47,54	1 331	70,3	1 591	86,99
32	17,57	292	0	552	20,09	812	39,05	1 072	46,79	1 332	70,05	1 592	86,81
33	15,53	293	0	553	21,63	813	40,76	1 073	46,13	1 333	69,66	1 593	87,14
34	13,77	294	0	554	22,78	814	41,82	1 074	45,73	1 334	69,26	1 594	86,81
35	12,95	295	0	555	23,59	815	42,12	1 075	45,17	1 335	68,73	1 595	86,85
36	12,95	296	0	556	24,23	816	42,08	1 076	44,43	1 336	67,88	1 596	87,03
37	13,35	297	0	557	24,9	817	42,27	1 077	43,59	1 337	66,68	1 597	86,92
38	13,75	298	0	558	25,72	818	43,03	1 078	42,68	1 338	65,29	1 598	87,14
39	13,82	299	0	559	26,77	819	44,14	1 079	41,89	1 339	63,95	1 599	86,92
40	13,41	300	0	560	28,01	820	45,13	1 080	41,09	1 340	62,84	1 600	87,03
41	12,26	301	0	561	29,23	821	45,84	1 081	40,38	1 341	62,21	1 601	86,99
42	9,82	302	0	562	30,06	822	46,4	1 082	39,99	1 342	62,04	1 602	86,96
43	5,96	303	0	563	30,31	823	46,89	1 083	39,84	1 343	62,26	1 603	87,03
44	2,2	304	0	564	30,29	824	47,34	1 084	39,46	1 344	62,87	1 604	86,85
45	0	305	0	565	30,05	825	47,66	1 085	39,15	1 345	63,55	1 605	87,1
46	0	306	0	566	29,44	826	47,77	1 086	38,9	1 346	64,12	1 606	86,81
47	0	307	0	567	28,6	827	47,78	1 087	38,67	1 347	64,73	1 607	87,03
48	0	308	0	568	27,63	828	47,64	1 088	39,03	1 348	65,45	1 608	86,77
49	0	309	0	569	26,66	829	47,23	1 089	40,37	1 349	66,18	1 609	86,99
50	1,87	310	0	570	26,03	830	46,66	1 090	41,03	1 350	66,97	1 610	86,96
51	4,97	311	0	571	25,85	831	46,08	1 091	40,76	1 351	67,85	1 611	86,96
52	8,4	312	0	572	26,14	832	45,45	1 092	40,02	1 352	68,74	1 612	87,07
53	9,9	313	0	573	27,08	833	44,69	1 093	39,6	1 353	69,45	1 613	86,96
54	11,42	314	0	574	28,42	834	43,73	1 094	39,37	1 354	69,92	1 614	86,92
55	15,11	315	0	575	29,61	835	42,55	1 095	38,84	1 355	70,24	1 615	87,07
56	18,46	316	0	576	30,46	836	41,14	1 096	37,93	1 356	70,49	1 616	86,92
57	20,21	317	0	577	30,99	837	39,56	1 097	37,19	1 357	70,63	1 617	87,14
58	22,13	318	0	578	31,33	838	37,93	1 098	36,21	1 358	70,68	1 618	86,96
59	24,17	319	0	579	31,65	839	36,69	1 099	35,32	1 359	70,65	1 619	87,03
60	25,56	320	0	580	32,02	840	36,27	1 100	35,56	1 360	70,49	1 620	86,85
61	26,97	321	0	581	32,39	841	36,42	1 101	36,96	1 361	70,09	1 621	86,77
62	28,83	322	0	582	32,68	842	37,14	1 102	38,12	1 362	69,35	1 622	87,1
63	31,05	323	0	583	32,84	843	38,13	1 103	38,71	1 363	68,27	1 623	86,92
64	33,72	324	3,01	584	32,93	844	38,55	1 104	39,26	1 364	67,09	1 624	87,07
65	36	325	8,14	585	33,22	845	38,42	1 105	40,64	1 365	65,96	1 625	86,85
66	37,91	326	13,88	586	33,89	846	37,89	1 106	43,09	1 366	64,87	1 626	86,81
67	39,65	327	18,08	587	34,96	847	36,89	1 107	44,83	1 367	63,79	1 627	87,14
68	41,23	328	20,01	588	36,28	848	35,53	1 108	45,33	1 368	62,82	1 628	86,77
69	42,85	329	20,3	589	37,58	849	34,01	1 109	45,24	1 369	63,03	1 629	87,03
70	44,1	330	19,53	590	38,58	850	32,88	1 110	45,14	1 370	63,62	1 630	86,96
71	44,37	331	17,92	591	39,1	851	32,52	1 111	45,06	1 371	64,8	1 631	87,1
72	44,3	332	16,17	592	39,22	852	32,7	1 112	44,82	1 372	65,5	1 632	86,99
73	44,17	333	14,55	593	39,11	853	33,48	1 113	44,53	1 373	65,33	1 633	86,92
74	44,13	334	12,92	594	38,8	854	34,97	1 114	44,77	1 374	63,83	1 634	87,1
75	44,17	335	11,07	595	38,31	855	36,78	1 115	45,6	1 375	62,44	1 635	86,85
76	44,51	336	8,54	596	37,73	856	38,64	1 116	46,28	1 376	61,2	1 636	86,92
77	45,16	337	5,15	597	37,24	857	40,48	1 117	47,18	1 377	59,58	1 637	86,77
78	45,64	338	1,96	598	37,06	858	42,34	1 118	48,49	1 378	57,68	1 638	86,88
79	46,16	339	0	599	37,1	859	44,16	1 119	49,42	1 379	56,4	1 639	86,63
80	46,99	340	0	600	37,42	860	45,9	1 120	49,56	1 380	54,82	1 640	86,85
81	48,19	341	0	601	38,17	861	47,55	1 121	49,47	1 381	52,77	1 641	86,63
82	49,32	342	0	602	39,19	862	49,09	1 122	49,28	1 382	52,22	1 642	86,77
83	49,7	343	0	603	40,31	863	50,42	1 123	48,58	1 383	52,48	1 643	86,77
84	49,5	344	0	604	41,46	864	51,49	1 124	48,03	1 384	52,74	1 644	86,55
85	48,98	345	0	605	42,44	865	52,23	1 125	48,2	1 385	53,14	1 645	86,59
86	48,65	346	0	606	42,95	866	52,58	1 126	48,72	1 386	53,03	1 646	86,55
87	48,65	347	0	607	42,9	867	52,63	1 127	48,91	1 387	52,55	1 647	86,7
88	48,87	348	0	608	42,43	868	52,49	1 128	48,93	1 388	52,19	1 648	86,44
89	48,97	349	0	609	41,74	869	52,19	1 129	49,05	1 389	51,09	1 649	86,7
90	48,96	350	0	610	41,04	870	51,82	1 130	49,23	1 390	49,88	1 650	86,55
91	49,15	351	0	611	40,49	871	51,43	1 131	49,28	1 391	49,37	1 651	86,33
92	49,51	352	0	612	40,8	872	51,02	1 132	48,84	1 392	49,26	1 652	86,48
93	49,74	353	0	613	41,66	873	50,61	1 133	48,12	1 393	49,37	1 653	86,19
94	50,31	354	0,9	614	42,48	874	50,26	1 134	47,8	1 394	49,88	1 654	86,37
95	50,78	355	2	615	42,78	875	50,06	1 135	47,42	1 395	50,25	1 655	86,59
96	50,75	356	4,08	616	42,39	876	49,97	1 136	45,98	1 396	50,17	1 656	86,55
97	50,78	357	7,07	617	40,78	877	49,67	1 137	42,96	1 397	50,5	1 657	86,7
98	51,21	358	10,25	618	37,72	878	48,86	1 138	39,38	1 398	50,83	1 658	86,63
99	51,6	359	12,77	619	33,29	879	47,53	1 139	35,82	1 399	51,23	1 659	86,55
100	51,89	360	14,44	620	27,66	880	45,82	1 140	31,85	1 400	51,67	1 660	86,59
101	52,04	361	15,73	621	21,43	881	43,66	1 141	26,87	1 401	51,53	1 661	86,55
102	51,99	362	17,23	622	15,62	882	40,91	1 142	21,41	1 402	50,17	1 662	86,7
103	51,99	363	19,04	623	11,51	883	37,78	1 143	16,41	1 403	49,99	1 663	86,55
104	52,36	364	20,96	624	9,69	884	34,89	1 144	12,56	1 404	50,32	1 664	86,7
105	52,58	365	22,94	625	9,46	885	32,69	1 145	10,41	1 405	51,05	1 665	86,52
106	52,47	366	25,05	626	10,21	886	30,99	1 146	9,07	1 406	51,45	1 666	86,85
107	52,03	367	27,31	627	11,78	887	29,31	1 147	7,69	1 407	52	1 667	86,55
108	51,46	368	29,54	628	13,6	888	27,29	1 148	6,28	1 408	52,3	1 668	86,81
109	51,31	369	31,52	629	15,33	889	24,79	1 149	5,08	1 409	52,22	1 669	86,74
110	51,45	370	33,19	630	17,12	890	21,78	1 150	4,32	1 410	52,66	1 670	86,63
111	51,48	371	34,67	631	18,98	891	18,51	1 151	3,32	1 411	53,18	1 671	86,77
112	51,29	372	36,13	632	20,73	892	15,1	1 152	1,92	1 412	53,8	1 672	87,03
113	51,12	373	37,63	633	22,17	893	11,06	1 153	1,07	1 413	54,53	1 673	87,07
114	50,96	374	39,07	634	23,29	894	6,28	1 154	0,66	1 414	55,37	1 674	86,92
115	50,81	375	40,08	635	24,19	895	2,24	1 155	0	1 415	56,29	1 675	87,07
116	50,86	376	40,44	636	24,97	896	0	1 156	0	1 416	57,31	1 676	87,18
117	51,34	377	40,26	637	25,6	897	0	1 157	0	1 417	57,94	1 677	87,32
118	51,68	378	39,29	638	25,96	898	0	1 158	0	1 418	57,86	1 678	87,36
119	51,58	379	37,23	639	25,86	899	0	1 159	0	1 419	57,75	1 679	87,29
120	51,36	380	34,14	640	24,69	900	0	1 160	0	1 420	58,67	1 680	87,58
121	51,39	381	30,18	641	21,85	901	0	1 161	0	1 421	59,4	1 681	87,61
122	50,98	382	25,71	642	17,45	902	2,56	1 162	0	1 422	59,69	1 682	87,76
123	48,63	383	21,58	643	12,34	903	4,81	1 163	0	1 423	60,02	1 683	87,65
124	44,83	384	18,5	644	7,59	904	6,38	1 164	0	1 424	60,21	1 684	87,61
125	40,3	385	16,56	645	4	905	8,62	1 165	0	1 425	60,83	1 685	87,65
126	35,65	386	15,39	646	1,76	906	10,37	1 166	0	1 426	61,16	1 686	87,65
127	30,23	387	14,77	647	0	907	11,17	1 167	0	1 427	61,6	1 687	87,76
128	24,08	388	14,58	648	0	908	13,32	1 168	0	1 428	62,15	1 688	87,76
129	18,96	389	14,72	649	0	909	15,94	1 169	0	1 429	62,7	1 689	87,8
130	14,19	390	15,44	650	0	910	16,89	1 170	0	1 430	63,65	1 690	87,72
131	8,72	391	16,92	651	0	911	17,13	1 171	0	1 431	64,27	1 691	87,69
132	3,41	392	18,69	652	0	912	18,04	1 172	0	1 432	64,31	1 692	87,54
133	0,64	393	20,26	653	0	913	19,96	1 173	0	1 433	64,13	1 693	87,76
134	0	394	21,63	654	0	914	22,05	1 174	0	1 434	64,27	1 694	87,5
135	0	395	22,91	655	0	915	23,65	1 175	0	1 435	65,22	1 695	87,43
136	0	396	24,13	656	0	916	25,72	1 176	0	1 436	66,25	1 696	87,47
137	0	397	25,18	657	0	917	28,62	1 177	0	1 437	67,09	1 697	87,5
138	0	398	26,16	658	2,96	918	31,99	1 178	0	1 438	68,37	1 698	87,5
139	0	399	27,41	659	7,9	919	35,07	1 179	0	1 439	69,36	1 699	87,18
140	0	400	29,18	660	13,49	920	37,42	1 180	0	1 440	70,57	1 700	87,36
141	0	401	31,36	661	18,36	921	39,65	1 181	0	1 441	71,89	1 701	87,29
142	0,63	402	33,51	662	22,59	922	41,78	1 182	0	1 442	73,35	1 702	87,18
143	1,56	403	35,33	663	26,26	923	43,04	1 183	0	1 443	74,64	1 703	86,92
144	2,99	404	36,94	664	29,4	924	43,55	1 184	0	1 444	75,81	1 704	87,36
145	4,5	405	38,6	665	32,23	925	42,97	1 185	0	1 445	77,24	1 705	87,03
146	5,39	406	40,44	666	34,91	926	41,08	1 186	0	1 446	78,63	1 706	87,07
147	5,59	407	42,29	667	37,39	927	40,38	1 187	0	1 447	79,32	1 707	87,29
148	5,45	408	43,73	668	39,61	928	40,43	1 188	0	1 448	80,2	1 708	86,99
149	5,2	409	44,47	669	41,61	929	40,4	1 189	0	1 449	81,67	1 709	87,25
150	4,98	410	44,62	670	43,51	930	40,25	1 190	0	1 450	82,11	1 710	87,14
151	4,61	411	44,41	671	45,36	931	40,32	1 191	0	1 451	82,91	1 711	86,96
152	3,89	412	43,96	672	47,17	932	40,8	1 192	0	1 452	83,43	1 712	87,14
153	3,21	413	43,41	673	48,95	933	41,71	1 193	0	1 453	83,79	1 713	87,07
154	2,98	414	42,83	674	50,73	934	43,16	1 194	0	1 454	83,5	1 714	86,92
155	3,31	415	42,15	675	52,36	935	44,84	1 195	0	1 455	84,01	1 715	86,88
156	4,18	416	41,28	676	53,74	936	46,42	1 196	1,54	1 456	83,43	1 716	86,85
157	5,07	417	40,17	677	55,02	937	47,91	1 197	4,85	1 457	82,99	1 717	86,92
158	5,52	418	38,9	678	56,24	938	49,08	1 198	9,06	1 458	82,77	1 718	86,81
159	5,73	419	37,59	679	57,29	939	49,66	1 199	11,8	1 459	82,33	1 719	86,88
160	6,06	420	36,39	680	58,18	940	50,15	1 200	12,42	1 460	81,78	1 720	86,66
161	6,76	421	35,33	681	58,95	941	50,94	1 201	12,07	1 461	81,81	1 721	86,92
162	7,7	422	34,3	682	59,49	942	51,69	1 202	11,64	1 462	81,05	1 722	86,48
163	8,34	423	33,07	683	59,86	943	53,5	1 203	11,69	1 463	80,72	1 723	86,66
164	8,51	424	31,41	684	60,3	944	55,9	1 204	12,91	1 464	80,61	1 724	86,74
165	8,22	425	29,18	685	61,01	945	57,11	1 205	15,58	1 465	80,46	1 725	86,37
166	7,22	426	26,41	686	61,96	946	57,88	1 206	18,69	1 466	80,42	1 726	86,48
167	5,82	427	23,4	687	63,05	947	58,63	1 207	21,04	1 467	80,42	1 727	86,33
168	4,75	428	20,9	688	64,16	948	58,75	1 208	22,62	1 468	80,24	1 728	86,3
169	4,24	429	19,59	689	65,14	949	58,26	1 209	24,34	1 469	80,13	1 729	86,44
170	4,05	430	19,36	690	65,85	950	58,03	1 210	26,74	1 470	80,39	1 730	86,33
171	3,98	431	19,79	691	66,22	951	58,28	1 211	29,62	1 471	80,72	1 731	86
172	3,91	432	20,43	692	66,12	952	58,67	1 212	32,65	1 472	81,01	1 732	86,33
173	3,86	433	20,71	693	65,01	953	58,76	1 213	35,57	1 473	81,52	1 733	86,22
174	4,17	434	20,56	694	62,22	954	58,82	1 214	38,07	1 474	82,4	1 734	86,08
175	5,32	435	19,96	695	57,44	955	59,09	1 215	39,71	1 475	83,21	1 735	86,22
176	7,53	436	20,22	696	51,47	956	59,38	1 216	40,36	1 476	84,05	1 736	86,33
177	10,89	437	21,48	697	45,98	957	59,72	1 217	40,6	1 477	84,85	1 737	86,33
178	14,81	438	23,67	698	41,72	958	60,04	1 218	41,15	1 478	85,42	1 738	86,26
179	17,56	439	26,09	699	38,22	959	60,13	1 219	42,23	1 479	86,18	1 739	86,48
180	18,38	440	28,16	700	34,65	960	59,33	1 220	43,61	1 480	86,45	1 740	86,48
181	17,49	441	29,75	701	30,65	961	58,52	1 221	45,08	1 481	86,64	1 741	86,55
182	15,18	442	30,97	702	26,46	962	57,82	1 222	46,58	1 482	86,57	1 742	86,66
183	13,08	443	31,99	703	22,32	963	56,68	1 223	48,13	1 483	86,43	1 743	86,66
184	12,23	444	32,84	704	18,15	964	55,36	1 224	49,7	1 484	86,58	1 744	86,59
185	12,03	445	33,33	705	13,79	965	54,63	1 225	51,27	1 485	86,8	1 745	86,55
186	11,72	446	33,45	706	9,29	966	54,04	1 226	52,8	1 486	86,65	1 746	86,74
187	10,69	447	33,27	707	4,98	967	53,15	1 227	54,3	1 487	86,14	1 747	86,21
188	8,68	448	32,66	708	1,71	968	52,02	1 228	55,8	1 488	86,36	1 748	85,96
189	6,2	449	31,73	709	0	969	51,37	1 229	57,29	1 489	86,32	1 749	85,5
190	4,07	450	30,58	710	0	970	51,41	1 230	58,73	1 490	86,25	1 750	84,77
191	2,65	451	29,2	711	0	971	52,2	1 231	60,12	1 491	85,92	1 751	84,65
192	1,92	452	27,56	712	0	972	53,52	1 232	61,5	1 492	86,14	1 752	84,1
193	1,69	453	25,71	713	0	973	54,34	1 233	62,94	1 493	86,36	1 753	83,46
194	1,68	454	23,76	714	0	974	54,59	1 234	64,39	1 494	86,25	1 754	82,77
195	1,66	455	21,87	715	0	975	54,92	1 235	65,52	1 495	86,5	1 755	81,78
196	1,53	456	20,15	716	0	976	55,69	1 236	66,07	1 496	86,14	1 756	81,16
197	1,3	457	18,38	717	0	977	56,51	1 237	66,19	1 497	86,29	1 757	80,42
198	1	458	15,93	718	0	978	56,73	1 238	66,19	1 498	86,4	1 758	79,21
199	0,77	459	12,33	719	0	979	56,33	1 239	66,43	1 499	86,36	1 759	78,48
200	0,63	460	7,99	720	0	980	55,38	1 240	67,07	1 500	85,63	1 760	77,49
201	0,59	461	4,19	721	0	981	54,99	1 241	68,04	1 501	86,03	1 761	76,69
202	0,59	462	1,77	722	0	982	54,75	1 242	69,12	1 502	85,92	1 762	75,92
203	0,57	463	0,69	723	0	983	54,11	1 243	70,08	1 503	86,14	1 763	75,08
204	0,53	464	1,13	724	0	984	53,32	1 244	70,91	1 504	86,32	1 764	73,87
205	0,5	465	2,2	725	0	985	52,41	1 245	71,73	1 505	85,92	1 765	72,15
206	0	466	3,59	726	0	986	51,45	1 246	72,66	1 506	86,11	1 766	69,69
207	0	467	4,88	727	0	987	50,86	1 247	73,67	1 507	85,91	1 767	67,17
208	0	468	5,85	728	0	988	50,48	1 248	74,55	1 508	85,83	1 768	64,75
209	0	469	6,72	729	0	989	49,6	1 249	75,18	1 509	85,86	1 769	62,55
210	0	470	8,02	730	0	990	48,55	1 250	75,59	1 510	85,5	1 770	60,32
211	0	471	10,02	731	0	991	47,87	1 251	75,82	1 511	84,97	1 771	58,45
212	0	472	12,59	732	0	992	47,42	1 252	75,9	1 512	84,8	1 772	56,43
213	0	473	15,43	733	0	993	46,86	1 253	75,92	1 513	84,2	1 773	54,35
214	0	474	18,32	734	0	994	46,08	1 254	75,87	1 514	83,26	1 774	52,22
215	0	475	21,19	735	0	995	45,07	1 255	75,68	1 515	82,77	1 775	50,25
216	0	476	24	736	0	996	43,58	1 256	75,37	1 516	81,78	1 776	48,23
217	0	477	26,75	737	0	997	41,04	1 257	75,01	1 517	81,16	1 777	46,51
218	0	478	29,53	738	0	998	38,39	1 258	74,55	1 518	80,42	1 778	44,35
219	0	479	32,31	739	0	999	35,69	1 259	73,8	1 519	79,21	1 779	41,97
220	0	480	34,8	740	0	1 000	32,68	1 260	72,71	1 520	78,83	1 780	39,33
221	0	481	36,73	741	0	1 001	29,82	1 261	71,39	1 521	78,52	1 781	36,48
222	0	482	38,08	742	0	1 002	26,97	1 262	70,02	1 522	78,52	1 782	33,8
223	0	483	39,11	743	0	1 003	24,03	1 263	68,71	1 523	78,81	1 783	31,09
224	0	484	40,16	744	0	1 004	21,67	1 264	67,52	1 524	79,26	1 784	28,24
225	0	485	41,18	745	0	1 005	20,34	1 265	66,44	1 525	79,61	1 785	26,81
226	0,73	486	41,75	746	0	1 006	18,9	1 266	65,45	1 526	80,15	1 786	23,33
227	0,73	487	41,87	747	0	1 007	16,21	1 267	64,49	1 527	80,39	1 787	19,01
228	0	488	41,43	748	0	1 008	13,84	1 268	63,54	1 528	80,72	1 788	15,05
229	0	489	39,99	749	0	1 009	12,25	1 269	62,6	1 529	81,01	1 789	12,09
230	0	490	37,71	750	0	1 010	10,4	1 270	61,67	1 530	81,52	1 790	9,49
231	0	491	34,93	751	0	1 011	7,94	1 271	60,69	1 531	82,4	1 791	6,81
232	0	492	31,79	752	0	1 012	6,05	1 272	59,64	1 532	83,21	1 792	4,28
233	0	493	28,65	753	0	1 013	5,67	1 273	58,6	1 533	84,05	1 793	2,09
234	0	494	25,92	754	0	1 014	6,03	1 274	57,64	1 534	85,15	1 794	0,88
235	0	495	23,91	755	0	1 015	7,68	1 275	56,79	1 535	85,92	1 795	0,88
236	0	496	22,81	756	0	1 016	10,97	1 276	55,95	1 536	86,98	1 796	0
237	0	497	22,53	757	0	1 017	14,72	1 277	55,09	1 537	87,45	1 797	0
238	0	498	22,62	758	0	1 018	17,32	1 278	54,2	1 538	87,54	1 798	0
239	0	499	22,95	759	0	1 019	18,59	1 279	53,33	1 539	87,25	1 799	0
240	0	500	23,51	760	0	1 020	19,35	1 280	52,52	1 540	87,04	1 800	0
241	0	501	24,04	761	0	1 021	20,54	1 281	51,75	1 541	86,98
242	0	502	24,45	762	0	1 022	21,33	1 282	50,92	1 542	87,05
243	0	503	24,81	763	0	1 023	22,06	1 283	49,9	1 543	87,1
244	0	504	25,29	764	0	1 024	23,39	1 284	48,68	1 544	87,25
245	0	505	25,99	765	0	1 025	25,52	1 285	47,41	1 545	87,25
246	0	506	26,83	766	0	1 026	28,28	1 286	46,5	1 546	87,07
247	0	507	27,6	767	0	1 027	30,38	1 287	46,22	1 547	87,29
248	0	508	28,17	768	0	1 028	31,22	1 288	46,44	1 548	87,14
249	0	509	28,63	769	0	1 029	32,22	1 289	47,35	1 549	87,03
250	0	510	29,04	770	0	1 030	33,78	1 290	49,01	1 550	87,25
251	0	511	29,43	771	0	1 031	35,08	1 291	50,93	1 551	87,03
252	0	512	29,78	772	1,6	1 032	35,91	1 292	52,79	1 552	87,03
253	1,51	513	30,13	773	5,03	1 033	36,06	1 293	54,66	1 553	87,07
254	4,12	514	30,57	774	9,49	1 034	35,5	1 294	56,6	1 554	86,81
255	7,02	515	31,1	775	13	1 035	34,76	1 295	58,55	1 555	86,92
256	9,45	516	31,65	776	14,65	1 036	34,7	1 296	60,47	1 556	86,66
257	11,86	517	32,14	777	15,15	1 037	35,41	1 297	62,28	1 557	86,92
258	14,52	518	32,62	778	15,67	1 038	36,65	1 298	63,9	1 558	86,59
259	17,01	519	33,25	779	16,76	1 039	37,57	1 299	65,2	1 559	86,92
260	19,48	520	34,2	780	17,88	1 040	38,51	1 300	66,02	1 560	86,59

ANNEX IV

4.3.2.4.Durability of emissions performance

4.3.5.Fuels

4.6.Requirements regarding compatibility with the NOx control measures (applicable only to replacement pollution control devices to be fitted to vehicles equipped with sensors directly measuring NOx concentration in the exhaust)

4.6.1.

4.6.2.

4.6.3.

4.6.4.

4.6.5.

‘Appendix 3Durability procedure for evaluation of emissions performance of a replacement pollution control device

1.

2.DESCRIPTION OF THE DURABILITY PROCEDURE

2.1.

2.2.Data collection phase

2.2.1.

2.2.2.

2.2.3.

2.2.4.

2.2.5.

2.2.6.

2.2.7.

2.2.8.

2.2.9.

2.2.10.

2.2.11.

2.2.12.

2.2.13.

2.2.14.

2.2.15.

2.3.Calculation of the equivalent ageing time corresponding to a reference temperature

2.3.1.

2.3.2.

2.3.3.

2.3.4.

2.3.5.

2.4.Service accumulation schedule

2.4.1.General requirements

2.4.1.1.

2.4.1.2.

2.4.1.3.

2.4.1.4.

2.4.1.5.

2.4.2.Thermal accumulation schedule

2.4.2.1.

2.4.2.2.

2.4.2.3.

2.4.2.4.

2.4.2.5.

2.4.2.6.

2.4.2.7.

2.4.2.8.

2.4.2.9.

2.4.2.10.

2.4.2.11.

2.4.3.Modified thermal accumulation schedule for devices operating in the presence of active regeneration

2.4.3.1.

2.4.3.2.

2.4.3.3.

2.4.3.4.

2.4.3.5.

2.4.3.6.

2.4.3.7.

2.4.3.8.

2.4.3.9.

2.4.3.10.

2.4.3.11.

2.4.3.12.

2.4.4.Lubricant consumption accumulation schedule

2.4.4.1.

2.4.4.2.

2.4.4.3.

2.4.4.4.

2.4.4.5.

2.4.4.6.

2.4.4.7.

2.4.4.8.Development of the lubricant consumption accumulation schedule

2.4.4.8.1.

2.4.4.8.2.

2.4.4.8.3.

2.4.4.8.4.

4.6.Requirements regarding compatibility with the NO_x control measures (applicable only to replacement pollution control devices to be fitted to vehicles equipped with sensors directly measuring NO_x concentration in the exhaust)